Adsorpsi Kromium Heksavalen Menggunakan Nanokomposit ZnO/Kitosan dari Limbah Baterai Zn-C dan Kulit Udang
DOI:
https://doi.org/10.32493/jitk.v9i2.48435Keywords:
Zn-C battery waste, shrimp shell, ZnO/chitosan nanocomposite, adsorption, hexavalent chromiumAbstract
Zn-C batteries contain zinc, carbon, manganese dioxide, and ammonium chloride, which are difficult to decompose and pose risks to human health and the environment. Recycling Zn-C battery waste into zinc oxide (ZnO) offers a sustainable solution. When combined with chitosan, ZnO forms a composite material. This study analyzes the characteristics of ZnO/chitosan nanocomposites and determines optimal conditions for hexavalent chromium adsorption. The nanocomposite was synthesized by mixing ZnO from battery waste with chitosan from shrimp shells. FTIR analysis of chitosan showed characteristic peaks at 3.498 cm⁻¹, 2.875 cm⁻¹, 1.373 cm⁻¹, 1.613 cm⁻¹, 1.302 cm⁻¹, 1.554 cm⁻¹, 1.153 cm⁻¹, and 1.067 cm⁻¹, while ZnO had a peak at 502 cm⁻¹. XRD analysis identified 2θ peaks at 9.22º, 19.13º, 23.04º, 26.23º, 31.62º, 34.39º, 36.17º, and 56.54º. Optimal adsorption occurred with 20 mg nanocomposite, 60 minutes contact time, and 5 ppm chromium concentration, achieving 94.61% efficiency.
References
Abbasabadi, O. R., Farahpour, M. R., & Tabatabaei, Z. G. (2022). Accelerative effect of nanohydrogels based on chitosan/ZnO incorporated with citral to heal the infected full-thickness wounds; an experimental study. International Journal of Biological Macromolecules, 217, 42–54. https://doi.org/https://doi.org/10.1016/j.ijbiomac.2022.07.038
Afandy, M. A., & Sawali, F. D. I. (2024). Adsorpsi Kromium Heksavalen Pada Larutan Aqueous Menggunakan Arang Kayu Teraktivasi Asam: Studi Isotherm Dan Kinetika. Jurnal Ilmiah Teknik Kimia, 8(1), 1–14. https://doi.org/10.32493/jitk.v8i1.35315
Agustina, S., Swantara, iI M. D., & Suartha, I. nyoman. (2015). Isolasi Kitin, Karakterisasi, dan Sintesis Kitosan Dari Kulit Udang. Jurnal Kimia, 9(2), 271–278.
Ali, S., Dayo, M., Alahmadi, S., & Mohamed, A. (2024). Chitosan-Supported ZnO Nanoparticles: Their Green Synthesis, Characterization, and Application for the Removal of Pyridoxine HCl (Vitamin B6) from Aqueous Media. Molecules, 29(4). https://doi.org/10.3390/molecules29040828
Amin, A., Khairi, N., & Allo, E. (2019). Sintesis dan karakterisai kitosan dari limbah cangkang udang sebagai stabilizer terhadap Ag nanopartikel. Fullerene Journal of Chemistry, 4(2), 86. https://doi.org/10.37033/fjc.v4i2.100
Amirmahani, N., Mahdizadeh, H., Seyedi, N., Nasiri, A., & Yazdanpanah, G. (2021). Synthesis and performance evaluation of chitosan/zinc oxide nanocomposite as a highly efficient adsorbent in the removal of reactive red 198 from water. Journal of the Chinese Chemical Society, 70(4), 869–878. https://doi.org/10.1002/jccs.202200514
Ayani, S. (2023). Biosintesis Nanopartikel ZnO menggunakan Ekstrak Daun Betadin ( Jatropha multifida L .) untuk Identifikasi Sidik Jari Laten. Seminar Nasional Kimia 2023 UIN Sunan Gunung Djati, 1–9.
Azizati, Z. (2019). Pembuatan dan Karakterisasi Kitosan Kulit Udang Galah. Walisongo Journal of Chemistry, 2(1), 10–16. https://doi.org/10.21580/wjc.v2i1.4043
Das, B. K., Das, P. K., Das, B. P., & Dash, P. (2021). Green technology to limit the effects of hexavalent chromium contaminated water bodies on public health and vegetation at industrial sites. Journal of Applied Biology and Biotechnology, 9(2), 28–35. https://doi.org/10.7324/JABB.2021.9203
Desnelli, D., Yulinda, L., Fernando, D., Fatma, F., Mara, A., & Said, M. (2023). Chitosan-ZnO Composite for Removal of Methylene Blue. Indonesian Journal of Fundamental and Applied Chemistry, 8(3), 133–138. https://doi.org/10.24845/ijfac.v8.i3.133
Fadhila, K. N., & Maharani, D. K. (2022). Preparasi dan Karakterisasi Komposit Kitosan-ZnO sebagai Agen Hidrofobik pada Kain Katun. UNESA Journal of Chemistry, 11(1), 69–76.
Imtihani, H. N., & Permatasari, S. N. (2020). Research Article Open Access Alfred. Simbiosa, 9(2), 129–137
Kurniawati, S., Nurjazuli, & Raharjo, M. (2017). Risiko Kesehatan Lingkungan Pencemaran Logam Berat Kromium Heksavalen (Cr VI) pada Ikan Nila (Oreochromis niloticus) di Aliran Sungai Garang Kota Semarang. Higiene, 3(3), 152–160.
Maharani, H., Hadisantoso, E. P., & Amalia, V. (2022). Sintesis dan Karakterisasi Hybrid- Biocomposite Zno/Kitosan untuk Aplikasi Penanganan Metilen Biru secara Fotokatalisis. Prosiding Seminar Nasional Kimia, 7, 123.
Mashuni, M., Ritonga, H., Jahiding, M., & Hamid, F. H. (2022). Sintesis Kitosan dari Kulit Udang sebagai Bahan Membran Elektrode Au/Kitosan/GTA/AChE untuk Deteksi Pestisida. Alchemy: Jurnal Penelitian Kimia, 18(1), 112. https://doi.org/10.20961/alchemy.18.1.56551.112-121
Ngamsurach, P., Namwongsa, N., & Praipipat, P. (2022). Synthesis of powdered and beaded chitosan materials modified with ZnO for removing lead (II) ions. Scientific Reports, 12(1), 1–19. https://doi.org/10.1038/s41598-022-22182-4
Raganata, T. C., Aritonang, H., & Suryanto, E. (2020). Sintesis Fotokatalis Nanopartikel ZnO untuk Mendegradasi Zat Warna Methlene Bluse. Chemistry Progress, 12(2), 54–58. https://doi.org/10.35799/cp.12.2.2019.27923
Sihombing, R. (2021). Konversi Seng Dari Limbah Baterai Zn-C Menjadi Senyawa Seng Sulfat. JC-T (Journal Cis-Trans): Jurnal Kimia Dan Terapannya, 5(2), 13–17. https://doi.org/10.17977/um0260v5i22021p013
Singh, S., Anil, A. G., Khasnabis, S., Kumar, V., Nath, B., Adiga, V., Kumar Naik, T. S. S., Subramanian, S., Kumar, V., Singh, J., & Ramamurthy, P. C. (2022). Sustainable removal of Cr(VI) using graphene oxide-zinc oxide nanohybrid: Adsorption kinetics, isotherms and thermodynamics. Environmental Abbasabadi, O. R., Farahpour, M. R., & Tabatabaei, Z. G. (2022). Accelerative effect of nanohydrogels based on chitosan/ZnO incorporated with citral to heal the infected full-thickness wounds; an experimental study. International Journal of Biological Macromolecules, 217, 42–54. https://doi.org/https://doi.org/10.1016/j.ijbiomac.2022.07.038
Afandy, M. A., & Sawali, F. D. I. (2024). Adsorpsi Kromium Heksavalen Pada Larutan Aqueous Menggunakan Arang Kayu Teraktivasi Asam: Studi Isotherm Dan Kinetika. Jurnal Ilmiah Teknik Kimia, 8(1), 1–14. https://doi.org/10.32493/jitk.v8i1.35315
Agustina, S., Swantara, iI M. D., & Suartha, I. nyoman. (2015). Isolasi Kitin, Karakterisasi, dan Sintesis Kitosan Dari Kulit Udang. Jurnal Kimia, 9(2), 271–278.
Ali, S., Dayo, M., Alahmadi, S., & Mohamed, A. (2024). Chitosan-Supported ZnO Nanoparticles: Their Green Synthesis, Characterization, and Application for the Removal of Pyridoxine HCl (Vitamin B6) from Aqueous Media. Molecules, 29(4). https://doi.org/10.3390/molecules29040828
Amin, A., Khairi, N., & Allo, E. (2019). Sintesis dan karakterisai kitosan dari limbah cangkang udang sebagai stabilizer terhadap Ag nanopartikel. Fullerene Journal of Chemistry, 4(2), 86. https://doi.org/10.37033/fjc.v4i2.100
Amirmahani, N., Mahdizadeh, H., Seyedi, N., Nasiri, A., & Yazdanpanah, G. (2021). Synthesis and performance evaluation of chitosan/zinc oxide nanocomposite as a highly efficient adsorbent in the removal of reactive red 198 from water. Journal of the Chinese Chemical Society, 70(4), 869–878. https://doi.org/10.1002/jccs.202200514
Ayani, S. (2023). Biosintesis Nanopartikel ZnO menggunakan Ekstrak Daun Betadin ( Jatropha multifida L .) untuk Identifikasi Sidik Jari Laten. Seminar Nasional Kimia 2023 UIN Sunan Gunung Djati, 1–9.
Azizati, Z. (2019). Pembuatan dan Karakterisasi Kitosan Kulit Udang Galah. Walisongo Journal of Chemistry, 2(1), 10–16. https://doi.org/10.21580/wjc.v2i1.4043
Das, B. K., Das, P. K., Das, B. P., & Dash, P. (2021). Green technology to limit the effects of hexavalent chromium contaminated water bodies on public health and vegetation at industrial sites. Journal of Applied Biology and Biotechnology, 9(2), 28–35. https://doi.org/10.7324/JABB.2021.9203
Desnelli, D., Yulinda, L., Fernando, D., Fatma, F., Mara, A., & Said, M. (2023). Chitosan-ZnO Composite for Removal of Methylene Blue. Indonesian Journal of Fundamental and Applied Chemistry, 8(3), 133–138. https://doi.org/10.24845/ijfac.v8.i3.133
Fadhila, K. N., & Maharani, D. K. (2022). Preparasi dan Karakterisasi Komposit Kitosan-ZnO sebagai Agen Hidrofobik pada Kain Katun. UNESA Journal of Chemistry, 11(1), 69–76.
Imtihani, H. N., & Permatasari, S. N. (2020). Research Article Open Access Alfred. Simbiosa, 9(2), 129–137.
Kurniawati, S., Nurjazuli, & Raharjo, M. (2017). Risiko Kesehatan Lingkungan Pencemaran Logam Berat Kromium Heksavalen (Cr VI) pada Ikan Nila (Oreochromis niloticus) di Aliran Sungai Garang Kota Semarang. Higiene, 3(3), 152–160.
Maharani, H., Hadisantoso, E. P., & Amalia, V. (2022). Sintesis dan Karakterisasi Hybrid- Biocomposite Zno/Kitosan untuk Aplikasi Penanganan Metilen Biru secara Fotokatalisis. Prosiding Seminar Nasional Kimia, 7, 123.
Mashuni, M., Ritonga, H., Jahiding, M., & Hamid, F. H. (2022). Sintesis Kitosan dari Kulit Udang sebagai Bahan Membran Elektrode Au/Kitosan/GTA/AChE untuk Deteksi Pestisida. Alchemy: Jurnal Penelitian Kimia, 18(1), 112. https://doi.org/10.20961/alchemy.18.1.56551.112-121
Ngamsurach, P., Namwongsa, N., & Praipipat, P. (2022). Synthesis of powdered and beaded chitosan materials modified with ZnO for removing lead (II) ions. Scientific Reports, 12(1), 1–19. https://doi.org/10.1038/s41598-022-22182-4
Raganata, T. C., Aritonang, H., & Suryanto, E. (2020). Sintesis Fotokatalis Nanopartikel ZnO untuk Mendegradasi Zat Warna Methlene Bluse. Chemistry Progress, 12(2), 54–58. https://doi.org/10.35799/cp.12.2.2019.27923
Sihombing, R. (2021). Konversi Seng Dari Limbah Baterai Zn-C Menjadi Senyawa Seng Sulfat. JC-T (Journal Cis-Trans): Jurnal Kimia Dan Terapannya, 5(2), 13–17. https://doi.org/10.17977/um0260v5i22021p013
Singh, S., Anil, A. G., Khasnabis, S., Kumar, V., Nath, B., Adiga, V., Kumar Naik, T. S. S., Subramanian, S., Kumar, V., Singh, J., & Ramamurthy, P. C. (2022). Sustainable removal of Cr(VI) using graphene oxide-zinc oxide nanohybrid: Adsorption kinetics, isotherms and thermodynamics. Environmental Research, 203, 111891. https://doi.org/10.1016/j.envres.2021.111891
Wijayanti, A., Susatyo, E. B., & Kurniawan, C. (2018). Adsorpsi Logam Cr(VI) Dan Cu(II) Pada Tanah Dan Pengaruh Penambahan Pupuk Organik. Indonesian Journal of Chemical Science, 7(3), 242–248.
Wisnuwijaya, R. I., Purwanto, A., & Sunu Brams Dwandaru, W. (2017). UV-Visible Optical Absorbance of Graphene Oxide Synthesized from Zinc-Carbon Battery Waste via a Custom-Made Ultrasound Generator based on Liquid Sonication Exfoliation Method. Makara Journal of Science, 21(4). https://doi.org/10.7454/mss.v21i4.6752
Wulandari, A., & Khabibi. (2023). Pengaruh Penambahan ZnO pada Kitosan Bead sebagai Adsorben Pencemar Ion Logam Pb(II). Greensphere: Journal Environmental Chemistry, 3(1), 9–13.
Wulandari, W. T., Nurzaman, Pratita, A. T. K., & Idacahyati, K. (2020). Pengaruh Variasi Konsentrasi NaOH Terhadap Nilai Derajat Deasetilasi Kitosan dari Limbah Cangkang Kerang Hijau (Perna viridis L). KOVALEN: Jurnal Riset Kimia, 6(3), 171–176. https://doi.org/10.22487/kovalen.2020.v6.i3.15277
Yang, X., Zhang, H., Cheng, S., & Zhou, B. (2022). Optimization of the adsorption and removal of Sb(iii) by MIL-53(Fe)/GO using response surface methodology. RSC Advances, 12(7), 4101–4112. https://doi.org/10.1039/d1ra08169a
Yunita, Y., Nurlina, N., & Syahbanu, I. (2020). Sintesis Nanopartikel Zink Oksida (ZnO) dengan Penambahan Ekstrak Klorofil sebagai Capping Agent. Positron, 10(2), 44. https://doi.org/10.26418/positron.v10i2.42136
Downloads
Published
How to Cite
Issue
Section
License
Copyright (c) 2025 Gaminingsih Gaminingsih, Sunardi Sunardi
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.
Authors who publish with this journal agree to the following terms:
1. Authors retain copyright and grant the journal right of first publication with the work simultaneously licensed under creativecommons.org/licenses/by-sa/4.0 that allows others to share the work with an acknowledgement of the work's authorship and initial publication in this journal.
2. Authors are able to enter into separate, additional contractual arrangements for the non-exclusive distribution of the journal's published version of the work (e.g., post it to an institutional repository or publish it in a book), with an acknowledgement of its initial publication in this journal.
Authors are permitted and encouraged to post their work online (e.g., in institutional repositories or on their website) prior to and during the submission process, as it can lead to productive exchanges, as well as earlier and greater citation of published work (See The Effect of Open Access).
Jurnal Ilmiah Teknik Kimia have CC-BY-SA or an equivalent license as the optimal license for the publication, distribution, use, and reuse of scholarly work.
In developing strategy and setting priorities, Jurnal Ilmiah Teknik Kimia recognize that free access is better than priced access, libre access is better than free access, and libre under CC-BY-SA or the equivalent is better than libre under more restrictive open licenses. We should achieve what we can when we can. We should not delay achieving free in order to achieve libre, and we should not stop with free when we can achieve libre.
Jurnal Ilmiah Teknik Kimia is licensed under a Creative Commons Attribution 4.0 International License
YOU ARE FREE TO:
- Share — copy and redistribute the material in any medium or format
- Adapt — remix, transform, and build upon the material for any purpose, even commercially.
- The licensor cannot revoke these freedoms as long as you follow the license terms.
